Mineralization characteristics of coal fly ash in the transition from non-supercritical CO2 to supercritical CO2

The accelerated mineralization of fly ash is a potential way to achieve CO 2 emissions reduction. However, the slow reaction at the diffusion control stage is the bottleneck. Due to the strong diffusion of supercritical CO 2 , it has been to strengthen mineralization, but the degree of improvement in mineralization efficiency and the changes that take place in the transition from non-supercritical to supercritical CO 2 are not clear. In the mineralization process, CaO in the ash reacts with CO 2 to form CaCO 3 . In order to exclude the influence of other alkaline oxides, powdered and block CaO were used to research the mechanism, and experiments were then carried out on samples of fly ash with different CaO content. Firstly, powdered CaO was used to conduct dry and wet mineralization experiments. In dry mineralization, the mineralization efficiency of the process changes in two stages as the pressure increases, first undergoing a gentle-increase and then a rapid one. Diffusion depth experiments on block CaO show that the supercritical diffusion depth is higher than the non-supercritical diffusion depth by a factor of 1.22, indicating that supercritical CO 2 can improve the degree of mineralization in diffusion stage. The presence of water could promote mineralization. In wet mineralization, the efficiency of the process changes in three stages as the pressure increases, with first a gentle increase then a more rapid one and finally an attenuated rate of increase. The supercritical mineralization efficiency at 8 MPa was 55.27%, a factor of 2.09 larger than for non-supercritical mineralization at 3 MPa (26.39%). This is because that supercritical CO 2 has increased the diffusion and greatly improved solubility in water. The results of DFT calculations show that H 2 O can promote the adsorption of CO 2 by CaO, which is one of the reasons why water promotes mineralization. Finally, wet mineralization experiments on fly ash show that at 8 MPa, the mineralization efficiencies of HB, SD, SX and YN fly ashes are 1.94, 1.30, 2.03 and 1.62 times their values at 3 MPa. Although the difference in efficiency is affected by the CaO content, supercritical CO 2 can effectively improve the mineralization efficiency.